When it comes to multi-pipe scrubbers, many friends may find it strange that it is a type of cyclone scrubber, often used in industrial boilers and thermal power station boilers, which are combined and used in one shell by many small cyclone scrubbers. So, what do you know about multiple devarnishers
Use and characteristics
Multi-barrel scrubbers are often used for dust management in various types of industrial boilers and boilers in thermoelectric power stations. For example, multibarrellers can be seen in recalcitrant furnaces, coal powder furnaces, cyclone stoves, fluid bed stoves, etc。
2. Even other industrial dusts may be recycled using multi-pipe scrubbers for cement and other practical dusts。
3. Large, adaptable loads, with a serviceable life of more than 20 years, long periods of time without congestion, simple maintenance, no running costs and small area of land, may be installed flexibly, either indoor or outdoor, depending on the user site。
4. Retrofitting of old dust removal equipment does not require the replacement of wind transmitters. In boiler dust management, it is available from 0. 5-670 tonnes/hour。
Ii. Rationale
Multi-pipe scrubbers are one of the types of cyclone-type dedustors, which are mainly made of porcelain materials, such as steering, exhausting, cyclones, etc., and when the dust gas enters the dedustor wind, the cyclone begins to rotate inside, separates the dust from the gas from the gas under centrifugal force, when the dust is landed in the dust tank, excavated by the airlocker, while the dry method is used to remove the dust and wet the dust. And dust can be used for recycling。
Iii. Use of care
1. Before turning on the scrubber, turn on the windmaker and, when the furnace is down, drop the windbreaker。
2. Discharge on time, with a four-hour period of ash, and if accumulated for too long, can easily cause dust congestion in dust containers。
3. The installation shall be baked for a period of three days at below 120°c, after which the construction of the water in the scrubber shall be separated and put into operation。
The article concludes: do you understand the information on multidiscretionors? It is hoped that the content shared by the authors will provide some information。
What, you still use your own money for the renovation? The renovations were phased, with an ultra-low annual interest rate of 3. 55 per cent and a maximum of $1 million. I'll apply for a discount immediately
What do you know about multiple scrubbers
